TR KLEENSCREEN PLUS® FILTRATION SYSTEM

BUILT-IN FILTER SYSTEM FOR 2TRF, 3TRF & 4TRF FRYERS

Model 2TR45CF

SPECIFICATIONS

Built-in filter system, Vulcan Model No. (# of fryers 2, 3, 4) TR (45, 65, 85) (control type A, D, or C) F (add suffix-F to fryer battery model No., i.e. 2TR45DF). Filter system accommodates maximum of four cabinets. Filter vessel constructed of drawn (seamless) 18 gauge series stainless steel. The 2TR45F filter pan weighs only

12.2 lbs. and the filter pan for the 2TR65 & TR85F weighs only

20.5 lbs. 1⁄3 H.P. motor/pump circulates hot frying compound at the rate of 8 gallons per minute, activated by a one touch push button switch. System provided standard with stainless steel mesh filter screen. Optional KleenScreen PLUS® envelopes filter out particulate down to .5 micron. Standard equipment comes on casters, has a tank brush, and clean-out rod. Hands free oil return line connection. Drain valve interlock switch turns fryer’s burners off when drain valve is opened. Requires 120 volt, 60 Hz, 1 phase power supply.

CSA design certified. NSF listed.

SPECIFY TYPE OF GAS WHEN ORDERING

Natural Gas Propane Gas

SPECIFY ALTITUDE

The TR Series fryer does not require any special adjustments for varying altitudes ranging from 0 – 10,000 feet for either Natural or Propane gas.

STANDARD FEATURES

• Filter system accommodates maximum of four fryer cabinets.
• Drain valve interlock switch – turns off gas burners automatically when draining oil.
• 6″ Casters adjustable – 2 locking, 2 non-locking.
• Drawn (seamless) 18 gauge stainless steel filter pan. 70 lbs. frying compound capacity on TR45F, 110 lbs. capacity on TR65 & TR85F.
• Stainless steel filter mesh screen filters from 2 sides; filter area = 270 square inches.
• ¹⁄3 H.P. motor and pump circulates frying compound at a rate of 8.0 gallons per minute.
• One touch push button switch to engage pump and motor.
• Tank brush and clean-out rod.
• 120 volt, 60 Hz, 1 phase (NEMA 5-15P).
• One year limited parts and labor warranty.
• 10 year fry tank limited warranty.
• 6′ High Temperature Discard Hose.

ACCESSORIES (Packaged & Sold Separately)

Stainless steel tank cover – doubles as a work surface top. Micro-Filtration Fabric Envelopes – 6 filters/per package. “Add-On” Frymate™ – VX15 or VX21S.

Rear oil reclamation discard connection (Factory Installed). TR45F – Twin Basket Lifts (Factory Installed).

TR65F & TR85F – Single and Twin Basket Lifts (Factory Installed).

Prison Security Package (Factory Installed). 11⁄4″ flexible gas hose with quick disconnect.

OPTIONS

Second year extended limited parts and labor warranty.

REFERENCE MATERIALS

• See 1TR45 Spec Sheet F45378.
• See 1TR65 Spec Sheet F45381.
• See 1TR85 Spec Sheet F45383.

TR KLEENSCREEN PLUS® FILTRATION SYSTEM

BUILT-IN FILTER SYSTEM FOR 2TRF, 3TRF & 4TRF FRYERS

INSTALLATION INSTRUCTIONS

1. A gas valve with internal pressure regulator is provided with this unit.
   • The supply pressure should be 7-9″ W.C. for natural gas and 11-12″ W.C. for propane gas
   • If incoming pressure exceeds 14″ W.C. (1⁄2 psig -3.45 kPa), a step-down pressure regulator must be installed
2. An adequate ventilation system is required for Commercial Cooking Equipment. Information may be obtained by writing

to the National Fire Protection Association, Batterymarch Park, Quincy, MA 02269. When writing refer to NFPA No. 96.

1. All models require a 6″ (152 mm) clearance at both sides and rear adjacent to combustible construction.
2. All models require a 16″ (407 mm) minimum clearance to adjacent open top burner units.
3. This appliance is manufactured for commercial installation only and is not intended for home use.

Service Connections:

11⁄₄” (32 mm) NPT common rear gas connection.

120 volt, 60 Hz, 1 phase electrical connection (NEMA 5-15P).

NOTE: In line with its policy to continually improve its product, Vulcan reserves the right to change materials and specifications without notice.

This appliance is manufactured for commercial use only and is not intended for home use.